Product ID:EZ WELD INDUSTRIAL GRADE PVC SOLVENT CEMENT
MSDS Date:02/20/1986
FSC:8040
NIIN:00N033474
MSDS Number: BPQJJ

PCI INDUSTRIES INC

1661 OLD DIXIE HIGHWAY
RIVIERA BEACH, FL 33404
US

Emergency Phone: 305-844-0241

Info Phone: 305-844-0241

Preparer: HARRY AUSTIN

Cage: FO174

PCI INDUSTRIES INC

9845 RIVIERA BEACH, FL 33419 US

Telephone: (407) 844-0241

Cage: FO174

FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (SARA III)

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 55%

OSHA PEL 200 PPM;250 PPM STEL

ACGIH TLV: 200 PPM;250 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

2-BUTANONE; (METHYL ETHYL KETONE)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 26%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 6%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LIQ INCIN.OTHERWISE, DILUTE W/H*2O & USING INERT

RTECS: 9999999ZZ

WASTE ACCORDING TO FEDERAL, STATE AND LOCAL

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50: (ORAL,RAT) 1620 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: POTNTL LOC & SYS EFTS DUE TO
SINGLE/SHORT TERM OVEREXP TO EYES & SKIN/THRU INHAL/INGEST. EYE:
CAUSES IRRIT,REDNESS, TEARING, BLURRED VISION. SKIN: CAN CAUSE
SLIGHT-MOD IRRIT & DEFAT (DRYNESS). INHAL: CAN CAUSE NASAL & RESP
IRRIT & HDCH. INGEST: CAN CAUSE GI IRRIT, NAUS, DIZZ, VOMIT &
DIARR. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: POTNTL LOC & SYS EFTS DUE TO
RPTD/LONG TERM OVEREXP TO EYES & SKIN/THRU INHAL/INGEST.EYE: MARKED
IRRIT (BURN), POSS TRANSIENT CORNEAL/CONJUNCTIVAL INJ. SKIN: SEV
IRRIT & DEFAT. CAN CAUSE RASH. INHAL: CAN CAUSE RESP IRRIT, VOMIT
& INCOORD. INGEST: CAUSES NAUS, VOMIT, HDCH, DIZZ, STUPOR,
DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE: IMMED FLUSH EYES W/PLENTY OF H*2O FOR AT LEAST 15 MIN.
CALL PHYS. SKIN: REMOVE CONTAM CLTHG PRIOR TO FLUSHING W/H*2O.
LAUNDER CONTAM CLTHG BEFORE RE-USE. WASH SKIN THORO W/MILD SOAP &
H*2O. INHAL : SEEK FRESH AIR. IF PERS IS AFFECTED, REMOVE TO FRESH
AIR.IF BRTHG IS DFCLT, ADMIN O*2 . IF BRTHG HAS STOPPED, GIVE ARTF
RESP.KEEP PERS WARM, QUIET & GET MED ATTN. INGEST: DO NOT INDUCE
(SUPDAT)

Flash Point Method:TCC
Flash Point:6F,-14C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:ALCOHOL RESISTANT FOAM, CARBON DIOXIDE OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER FLAME,
SPARKS, HEATERS, SMOKING, ELEC MOTORS, STATIC (SUPDAT)

Spill Release Procedures:EXTING & DO NOT TURN ON ANY IGNIT SOURCE UNTIL
AREA IS DETERM TO BE FREE FROM EXPLO/FIRE HAZ.SML SPILL:ABSORB
W/EARTH, SAND/SIMILAR INERT MATL & DISP OF W/SOLID WASTE ACCORD TO
FED, ST & LOC REGS.FLUS H SPILL AREA W/H*2O. LRG SPILL:ERECT TEMP
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS,& FLAME.
AVOID BRTHG VAP.AVOID CONT W/EYES,SKIN,& CLTHG. KEEP CNTNR CLSD.USE
W/ADEQ VENT. WASH THOROUGHLY AFTER USING.
Other Precautions:CNTNRS OF MATERIAL MAY BE HAZARDOUS WHEN EMPTIED
SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID,
AND/OR SOLID). ALL HAZARD PRECAUTIONS GIVEN IN DATA SHEET ABOVE
MUST BE OBSERVED.

Respiratory Protection:IF TLV OF PROD OR ANY COMPONENT OF IT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CNTRL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPROVED RESPIRAT ORS UNDER SPECIFIED CONDITIONS.
Ventilation:IF PRODUCT IS USED IN CONFINED AREA,PROVIDE SUFF MECH (GEN
&/OR LOC EXHST) VENT TO MAINTAIN EXPOS BELOW TLV(S). (SUPDAT)
Protective Gloves:RUBBER,BUTYL OR OTHER IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE BATH, SAFETY SHOWER, FACE SHIELD, RUBBER
SAFETY BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: DISCHARGE, OR OTHER IGNIT SOURCES AT LOCATIONS DISTANT FROM
MATL HNDLG POINT. FIRST AID PROC: VOMIT.IF PERSON IS CONSCIOUS,
DILUTE BY GIVING 2 GLASSES OF H*2O. CALL PHYS. KEEP PERSON WARM &
QUIET. VENT: EXPLO PROOF EQUIP IS ADVISED. SPILL PROC: (OR PERM)
DIKE TO CONTAIN SPILL. COLLECT & DESTROY BY (ING 4)

Boiling Pt:B.P. Text:150F,66C
Vapor Pres:114 @ 63F
Vapor Density:2.5
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:4 (N-BUTYL ACETATE=1)
Solubility in Water:65%
Appearance and Odor:MILKY COLORED LIQUID WITH STRONG SOLVENT ODOR.
Percent Volatiles by Volume:87

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CO*2, CO AND
VARIOUS HYDROCARBONS.

Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. IF PERMITS AND REGULATIONS ALLOW, MAY BE INCINERATED,
ALLOWED TO EVAPORATE OR SOLIDIFIED WITH INERT MATERIAL AND DISPOSED
OF.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.